日本中文字幕视频在线看-日本中文字幕网站-日本中文字幕一区二区-日本中文字幕一区二区高清在线-日本中文字幕一区二区有码在线-日本中文字幕永久在线

歡迎訪問永誠廣建公路材料(山東)有限公司網站!

永誠廣建公路材料(山東)有限公司

熱線電話

15165180688

您現在所在的位置 :首頁 - 新聞中心 > 行業資訊

行業資訊

水泥穩定碎石怎么取不出完整的芯樣?

來源:http://m.yuanchuodian.cn/ 日期:2023-01-04
按照技術規范要求,濟南水泥穩定碎石層齡期7d~10d,應能取出完整的鉆件,可實際情況是部分路段因為松散,不能取出完整的芯樣。其原因是什么呢?
According to the requirements of the technical specifications, the Jinan cement stabilized macadam layer has an age of 7d~10d, and it should be able to take out complete drill pieces. However, the actual situation is that some sections cannot take out complete core samples because they are loose. What is the reason?
1)水泥用量偏少造成骨料之間膠結不好,達不到強度;
1) The cement consumption is too small, resulting in poor cementation between aggregates and failure to reach the strength;
2)沒有完全按照規范要求進行養護,按規范要求每一段碾壓完成并經壓實度檢查合格后,應立即養生,宜采用濕砂進行養生,砂層厚度為7cm~10cm。也可采用瀝青乳液進行養生,無述條件時,也可用灑水車結常灑水進行養生。養生期不宜少于7天;
2) If the curing is not carried out in full accordance with the specification requirements, the curing shall be carried out immediately after the compaction of each section is completed according to the specification requirements and the compactness is checked to be qualified. It is better to use wet sand for curing. The thickness of the sand layer is 7cm~10cm. Asphalt lotion can also be used for curing. If there are no conditions mentioned above, the watering cart can also be used for curing. The curing period should not be less than 7 days;
3)水泥穩定碎石層原材料級配不好;
3) The raw materials of cement stabilized macadam are poorly graded;
4)含水量不合適,以至于水泥不能在混合料中完全水化和水解,水泥對碎石的穩定作用沒發揮,影響水泥穩定碎石的強度;
4) The water content is not appropriate, so that the cement cannot be fully hydrated and hydrolyzed in the mixture, and the cement does not play a role in stabilizing the crushed stone, affecting the strength of cement stabilized crushed stone;
5)水泥選用不當,普通硅酸鹽水泥,礦渣硅酸鹽水泥和火山灰質硅酸鹽水泥都可用水泥穩定碎石,但應選用初凝時間3h以上和終凝時間較長(宜在6h以上)。不宜使用快硬水泥,早強水泥以及已受潮變質的水泥;
5) Improper cement selection. Ordinary Portland cement, slag Portland cement and pozzolanic Portland cement can be used to stabilize crushed stone, but the initial setting time shall be more than 3h and the final setting time shall be longer (preferably more than 6h). Fast hardening cement, early strength cement and cement that has been damped and deteriorated should not be used;
6)拌合得不均勻,且沒在佳含水量下充分壓實,以及施工碾壓時間拖的過長,破壞了已結硬的水泥膠凝,使其強度下降。
6) Uneven mixing, insufficient compaction under good water content, and too long construction rolling time destroy the hardened cement gel and reduce its strength.
濟南水泥穩定碎石
預防措施:
Preventive measures:
1)原材料方面,每批水泥應檢驗合格后,才能進行使用;對于碎石,要符合級配要求,大料徑不要超過31.5mm,對于不合格的材料嚴禁進入場地;
1) In terms of raw materials, each batch of cement can only be used after passing the inspection; Crushed stone shall meet the grading requirements, and the large material diameter shall not exceed 31.5mm. Unqualified materials shall not enter the site;
2)改進拌合工藝,盡量避免離析的產生,施工人員要加強對水泥劑的控制,發現了問題要及時改進與處理;
2) The mixing process shall be improved to avoid segregation as much as possible. The construction personnel shall strengthen the control of the cement agent, and timely improve and handle the problems found;
3)抖合的計量器具要在開工前送計量質量檢測中心進行檢定,以保證稱量的準確無誤;
3) Shattered measuring instruments shall be sent to the Measurement Quality Inspection Center for verification before commencement to ensure the accuracy of weighing;
4)在運輸過程中要避免使用小型送料車,混合料要覆蓋,減少運輸途中水分的蒸發。
4) Small feeder trucks shall be avoided during transportation, and the mixture shall be covered to reduce evaporation of water during transportation.
水泥穩定碎石基層這些質量問題的出現,就要求操作人員應該對每道工序要嚴格控制,只有這樣才能保證水泥穩定碎石層的質量,避免病害的產生。更多相關內容就來我們網站http://m.yuanchuodian.cn咨詢了解吧!
The occurrence of these quality problems of cement stabilized macadam base requires operators to strictly control each process. Only in this way can the quality of cement stabilized macadam be guaranteed and the occurrence of diseases be avoided. More relevant content will come to our website http://m.yuanchuodian.cn Ask and understand!
  • 上一條:壓路機啟動馬達的維護要點
  • 下一條:新鋪瀝青混合料面層異常現象與防治措施
  • 相關產品:

    主站蜘蛛池模板: 麻豆美女大尺度啪啪 | 欧美高清xx | 超级在线牛碰碰视频 | 日本视频免费观看 | 日韩v| 97国产精品 | 日本免费不卡在线一区二区三区 | www操| 亚洲国产成+人+综合 | 久久久精品久久久久久久久久久 | 99久久精品免费看国产情侣 | 天天摸日日摸 | 国产成人一区二区三区小说 | 国产露脸3pwww福利视频 | 日本在线精品 | 欧美日韩综合网 | 午夜小视频在线播放 | 国产精品亚洲第一区在线28石 | 国产亚洲欧美在线人成aaaa | 亚洲色p| 天天做人人爱夜夜爽2020毛片 | 欧美特级毛片a够爽 | 亚洲在线免费观看视频 | 欧美高清一级毛片免费视 | 狠狠操网站 | 欧美色欧美亚洲高清在线视频 | 国产精品久久精品牛牛影视 | 青青在线成人免费视频 | 欧美高清免费一级在线 | 欧美成人精品一级高清片 | 97久视频精品视频在线老司机 | 久久福利小视频 | 91激情在线 | 精品欧美日韩一区二区 | 精品视频一区二区在线视频 | 国产合集福利视频在线视频 | 久久综合狠狠色综合伊人 | 青青青永久免费视频 | 日本一区二区三区在线 视频观看免费 | 91久久偷偷做嫩草影院免费 | 天天干中文字幕 |